NTSB says systemic errors led to I-5 bridge collapse

WASHINGTON — Insufficient route planning, a distracted pilot driver and an inadequate permitting process by the state of Washington all played a part in last year’s I-5 bridge collapse, which sent two cars into the Skagit River, the National Transportation Safety Board said Tuesday.

The board voted unanimously after a nearly two-hour hearing to issue a number of recommendations, including encouraging states to ban nonessential cellphone use by pilot car drivers and requiring better warnings of low-clearance bridges, as well as lane-specific guidance for bridge clearance.

A section of the bridge fell into the water in May 2013 after a truck carrying a tall load hit the bridge in Mount Vernon, about 60 miles north of Seattle. Two other vehicles fell into the Skagit River, and three people were rescued with minor injuries.

Chris Hart, acting chairman of the four-member board, said the wide-ranging report provided by NTSB staff showed the “many missed opportunities to prevent this accident.”

“Movement of oversized loads is a specialized operation that demands special precautions,” he said. “What this investigation uncovered were multiple gaps in multiple systems.”

Board member Mark Rosekind said the report showed “there were holes in every one of these slices of cheese.”

William Scott, who was driving the truck with the tall load for Mullen Trucking, told investigators a freight truck came up fast on his left. He said he drove to the bridge’s right side, which had a lower vertical clearance than the center lane.

According to the investigation, Scott thought his load was 15 feet, 9 inches — about 2 inches shorter than it actually was. The top of the load collided with the far right side of the overhead truss structure.

The state Department of Transportation automatically issued Mullen Trucking an oversize-load permit over the Internet, without review and without comparing the given dimensions to the proposed route, according to Tuesday’s staff presentation.

NTSB staff noted an automatic permit process does not motivate carriers to conduct route surveys ahead of time to ensure their loads are within the clearance limits.

The pilot vehicle’s driver, Tammy Detray, told investigators the clearance pole mounted on her vehicle never struck the bridge. She also said she was using her cellphone on a hands-free device at the time of the accident.

“Her entire reason for being there was to protect the oversize vehicle and the vehicles that shared the roadway with her, and yet she jeopardized the safety of others because of a cellphone call,” board member Robert Sumwalt said.

Sumwalt asked staff whether the accident could have been avoided if Detray had notified Scott of the low clearance. He was told Scott was following Detray too closely to stop safely.

The investigation showed Scott was about 400 feet, or about five seconds, behind the pilot car, instead of the 865 feet, or 10 seconds, he should have been trailing by.

Safety recommendations also approved by the board include asking the Federal Highway Administration to develop a guide for states on how to prevent bridge strikes, including collecting and sharing data, and evaluating and reviewing bridge strike countermeasures.

In a written statement, state Department of Transportation Secretary Lynn Peterson said the agency already has started working on improving access to data for the freight industry, and would work with the industry and Legislature for any recommendations that require legislative action.

“We all aim to provide the safest conditions possible for the traveling public,” she wrote.

As for the other changes, including to the permitting process oversight, spokesman Lars Erickson said the department will move on making revisions. “That’s our commitment,” he said.

The 59-year-old Skagit bridge carries an average of 71,000 vehicles a day over the river on I-5. Workers installed an emergency span and then replaced it with a permanent one in September.

Talk to us

> Give us your news tips.

> Send us a letter to the editor.

> More Herald contact information.

More in Local News

A firefighter stands in silence before a panel bearing the names of L. John Regelbrugge and Kris Regelbrugge during the ten-year remembrance of the Oso landslide on Friday, March 22, 2024, at the Oso Landslide Memorial in Oso, Washington. (Ryan Berry / The Herald)
‘Flood of emotions’ as Oso Landslide Memorial opens on 10th anniversary

Friends, family and first responders held a moment of silence at 10:37 a.m. at the new 2-acre memorial off Highway 530.

Julie Petersen poses for a photo with images of her sister Christina Jefferds and Jefferds’ grand daughter Sanoah Violet Huestis next to a memorial for Sanoah at her home on March 20, 2024 in Arlington, Washington. Peterson wears her sister’s favorite color and one of her bangles. (Annie Barker / The Herald)
‘It just all came down’: An oral history of the Oso mudslide

Ten years later, The Daily Herald spoke with dozens of people — first responders, family, survivors — touched by the deadliest slide in U.S. history.

Victims of the Oso mudslide on March 22, 2014. (Courtesy photos)
Remembering the 43 lives lost in the Oso mudslide

The slide wiped out a neighborhood along Highway 530 in 2014. “Even though you feel like you’re alone in your grief, you’re really not.”

Director Lucia Schmit, right, and Deputy Director Dara Salmon inside the Snohomish County Department of Emergency Management on Friday, March 8, 2024, in Everett, Washington. (Ryan Berry / The Herald)
How Oso slide changed local emergency response ‘on virtually every level’

“In a decade, we have just really, really advanced,” through hard-earned lessons applied to the pandemic, floods and opioids.

Ron and Gail Thompson at their home on Monday, March 4, 2024 in Oso, Washington. (Olivia Vanni / The Herald)
In shadow of scarred Oso hillside, mudslide’s wounds still feel fresh

Locals reflected on living with grief and finding meaning in the wake of a catastrophe “nothing like you can ever imagine” in 2014.

Everett mall renderings from Brixton Capital. (Photo provided by the City of Everett)
Topgolf at the Everett Mall? Mayor’s hint still unconfirmed

After Cassie Franklin’s annual address, rumors circled about what “top” entertainment tenant could be landing at Everett Mall.

Everett
Everett man sentenced to 3 years of probation for mutilating animals

In 2022, neighbors reported Blayne Perez, 35, was shooting and torturing wildlife in north Everett.

Dorothy Crossman rides up on her bike to turn in her ballot  on Tuesday, Aug. 1, 2023 in Everett, Washington. (Olivia Vanni / The Herald)
Everett leaders plan to ask voters for property tax increase

City officials will spend weeks hammering out details of a ballot measure, as Everett faces a $12.6 million deficit.

Starbucks employee Zach Gabelein outside of the Mill Creek location where he works on Friday, Feb. 23, 2024 in Mill Creek, Washington. (Olivia Vanni / The Herald)
Mill Creek Starbucks votes 21-1 to form union

“We obviously are kind of on the high of that win,” store bargaining delegate Zach Gabelein said.

Lynnwood police respond to a collision on highway 99 at 176 street SW. (Photo provided by Lynnwood Police)
Police: Teen in stolen car flees cops, causes crash in Lynnwood

The crash blocked traffic for over an hour at 176th Street SW. The boy, 16, was arrested on felony warrants.

The view of Mountain Loop Mine out the window of a second floor classroom at Fairmount Elementary on Wednesday, Jan. 10, 2024 in Everett, Washington. (Olivia Vanni / The Herald)
County: Everett mining yard violated order to halt work next to school

At least 10 reports accused OMA Construction of violating a stop-work order next to Fairmount Elementary. A judge will hear the case.

Imagine Children's Museum's incoming CEO, Elizabeth "Elee" Wood. (Photo provided by Imagine Children's Museum)
Imagine Children’s Museum in Everett to welcome new CEO

Nancy Johnson, who has led Imagine Children’s Museum in Everett for 25 years, will retire in June.

Support local journalism

If you value local news, make a gift now to support the trusted journalism you get in The Daily Herald. Donations processed in this system are not tax deductible.